Advertise on DISCO3.CO.UK
Forum · Gallery · Wiki · Shop · Sponsors
DISCO3.CO.UK > FS: Parts & Accessories

[For Sale] FBH Controller - Using Key fob 3rd button.
Post Reply  Down to end
Page 10 of 15 <123 ... 91011 ... 131415>
gruodiz
 


Member Since: 16 Nov 2011
Location: Klaipeda
Posts: 294

Lithuania 2006 Discovery 3 TDV6 HSE Auto Buckingham BlueDiscovery 3

discostick, this is one of the first modules from you.

no other lights on the module, just blue blinking and then stop.

it happeneds most after night, it didn't start this morning as well but started ok for other 3 times during day time when left for 2-3hrs.

how does it let me know if battery voltage is too low?

I left doors open but latch shut, I left bonnet open and bonnet RH latch shut where open/close sensor is to let the car think that everything is closed and locked the vehicle. I'll check voltage at the battery and at module wiring connector. I did installed extra connector in about 10cm from module if I need to remove it but wiring loom left in the car.

My car is LHD so battery in RH, FBH in same LH side. I wired red 12+ and ground- to FBH live, blue to headlight, ignition to headlight as well as mine is adaptive headlights and there's IGN wire for that. Everything wired very nice soldered, wires in black corrugated pipe, factory look, no hanging colored wires in engine bay Thumbs Up

edit: orange to FBH as shown in instruction
 Discovery 3 TDV8 3.6 facelifted to MY14  
Post #15895438th Jan 2016 5:16 pm
View user's profile Send private message View poster's gallery Reply with quote
discostick
 


Member Since: 08 Nov 2012
Location: Kent
Posts: 286

United Kingdom 2005 Discovery 3 TDV6 S Manual Bonatti GreyDiscovery 3

Your right, i just looked and you were in fact The first person to buy one. You actually have my first prototype Smile

There were some software changes between yours and the first batch i sold, i just looked through the log of changes and i have some ideas.

First though, do you have Xenon or Halogen lights? One guy on here had a problem with flickering Xenon lights, the flicker was giving the module false start / stop signals.

If you are confident your lights are all good, try this:

Change the DIP switch setting in the module to either:
45 minute setting. 1 = ON, 2 = ON
30 minute setting, 1 = OFF, 2 = ON.

I assume you have it set to temperature target, 1= ON, 2 = OFF ?

If this fixes the problem, then i know how to fix it for you.

Let me know

James
 New Engine - Fitted with body on...

Developer of the FBH Smart Control Module - Keyfob 3rd button control + USB Diagnostics + remote status LED + priming + battery protection + water temp control setpoint (or fixed run time)

Group Buy: www.disco3.co.uk/forum/post1405044.html#1405044
Downloads: www.dropbox.com/sh/swqlepn6jdb7g5l/AAD5avF_KIexlhlQf4--kysZa?dl=0
FBH not Starting?: www.disco3.co.uk/forum/fixed-webasto-fbh-105563.html
E: d3discostick@gmail.com 
 
Post #15895688th Jan 2016 6:01 pm
View user's profile Send private message View poster's gallery Send e-mail Reply with quote
discostick
 


Member Since: 08 Nov 2012
Location: Kent
Posts: 286

United Kingdom 2005 Discovery 3 TDV6 S Manual Bonatti GreyDiscovery 3

you would know if there is a battery voltage problem by the red LED flashing after the start attempt.
 New Engine - Fitted with body on...

Developer of the FBH Smart Control Module - Keyfob 3rd button control + USB Diagnostics + remote status LED + priming + battery protection + water temp control setpoint (or fixed run time)

Group Buy: www.disco3.co.uk/forum/post1405044.html#1405044
Downloads: www.dropbox.com/sh/swqlepn6jdb7g5l/AAD5avF_KIexlhlQf4--kysZa?dl=0
FBH not Starting?: www.disco3.co.uk/forum/fixed-webasto-fbh-105563.html
E: d3discostick@gmail.com 
 
Post #15895708th Jan 2016 6:02 pm
View user's profile Send private message View poster's gallery Send e-mail Reply with quote
gruodiz
 


Member Since: 16 Nov 2011
Location: Klaipeda
Posts: 294

Lithuania 2006 Discovery 3 TDV6 HSE Auto Buckingham BlueDiscovery 3

My headlights are adaptive xenon and as I wrote I took ignition from headlight.

The first Rolling with laughter Rolling with laughter
 Discovery 3 TDV8 3.6 facelifted to MY14  
Post #15896658th Jan 2016 8:50 pm
View user's profile Send private message View poster's gallery Reply with quote
gruodiz
 


Member Since: 16 Nov 2011
Location: Klaipeda
Posts: 294

Lithuania 2006 Discovery 3 TDV6 HSE Auto Buckingham BlueDiscovery 3

How should I notice xenon flickering?
 Discovery 3 TDV8 3.6 facelifted to MY14  
Post #15896808th Jan 2016 9:09 pm
View user's profile Send private message View poster's gallery Reply with quote
discostick
 


Member Since: 08 Nov 2012
Location: Kent
Posts: 286

United Kingdom 2005 Discovery 3 TDV6 S Manual Bonatti GreyDiscovery 3

I think it would be obvious just looking at the lights.
It was a while ago but i think he had retro-fitted xenon....

I havent looked at how the wiring for the xenon is, it seems unlikely that a flickering would actually effect the voltage on the wire you are tapped into, it might of been the fact he had retro-fitted them somehow. Last i heard he switched back to halogen and it was working fine again.

If you dont see a flickering, i would change the switches in the module and see if that resolves it.
 New Engine - Fitted with body on...

Developer of the FBH Smart Control Module - Keyfob 3rd button control + USB Diagnostics + remote status LED + priming + battery protection + water temp control setpoint (or fixed run time)

Group Buy: www.disco3.co.uk/forum/post1405044.html#1405044
Downloads: www.dropbox.com/sh/swqlepn6jdb7g5l/AAD5avF_KIexlhlQf4--kysZa?dl=0
FBH not Starting?: www.disco3.co.uk/forum/fixed-webasto-fbh-105563.html
E: d3discostick@gmail.com 
 
Post #15896928th Jan 2016 9:23 pm
View user's profile Send private message View poster's gallery Send e-mail Reply with quote
gruodiz
 


Member Since: 16 Nov 2011
Location: Klaipeda
Posts: 294

Lithuania 2006 Discovery 3 TDV6 HSE Auto Buckingham BlueDiscovery 3

First thing to do Thumbs Up
 Discovery 3 TDV8 3.6 facelifted to MY14  
Post #15896938th Jan 2016 9:25 pm
View user's profile Send private message View poster's gallery Reply with quote
gruodiz
 


Member Since: 16 Nov 2011
Location: Klaipeda
Posts: 294

Lithuania 2006 Discovery 3 TDV6 HSE Auto Buckingham BlueDiscovery 3

I set dips to 30mins yesterday and this morning FBH started with 3rd button at first attempt. I left car still locked, untouched, engine didn't run as well and I will try to start it again in couple hrs.

Any ideas, discostick? Very Happy
 Discovery 3 TDV8 3.6 facelifted to MY14  
Post #15897899th Jan 2016 8:55 am
View user's profile Send private message View poster's gallery Reply with quote
gruodiz
 


Member Since: 16 Nov 2011
Location: Klaipeda
Posts: 294

Lithuania 2006 Discovery 3 TDV6 HSE Auto Buckingham BlueDiscovery 3

2nd attempt and FBH starts again Thumbs Up
 Discovery 3 TDV8 3.6 facelifted to MY14  
Post #15898409th Jan 2016 11:06 am
View user's profile Send private message View poster's gallery Reply with quote
discostick
 


Member Since: 08 Nov 2012
Location: Kent
Posts: 286

United Kingdom 2005 Discovery 3 TDV6 S Manual Bonatti GreyDiscovery 3

Thumbs Up

Run it for a few days in that mode to be sure it's corrected.
 New Engine - Fitted with body on...

Developer of the FBH Smart Control Module - Keyfob 3rd button control + USB Diagnostics + remote status LED + priming + battery protection + water temp control setpoint (or fixed run time)

Group Buy: www.disco3.co.uk/forum/post1405044.html#1405044
Downloads: www.dropbox.com/sh/swqlepn6jdb7g5l/AAD5avF_KIexlhlQf4--kysZa?dl=0
FBH not Starting?: www.disco3.co.uk/forum/fixed-webasto-fbh-105563.html
E: d3discostick@gmail.com 
 
Post #15898509th Jan 2016 11:30 am
View user's profile Send private message View poster's gallery Send e-mail Reply with quote
gruodiz
 


Member Since: 16 Nov 2011
Location: Klaipeda
Posts: 294

Lithuania 2006 Discovery 3 TDV6 HSE Auto Buckingham BlueDiscovery 3

I have no other choice until I receive new chip from you Very Happy
 Discovery 3 TDV8 3.6 facelifted to MY14  
Post #15898579th Jan 2016 12:03 pm
View user's profile Send private message View poster's gallery Reply with quote
bobmclane
 


Member Since: 27 Dec 2014
Location: Ipswich
Posts: 48

United Kingdom 2005 Discovery 3 TDV6 SE Manual Java BlackDiscovery 3

Hi discostick/James,
Are you still making these awesome bits of kit as I'd like one?? The disco 3 is playing up with the glow plugs and at a cost of £1800 potentially quoted in case they snap in the head I like to give one of these beauties a go Smile
If you aren't selling them still do you have the docs on parts and how to build as happy to give it a go myself...?
Cheers
Bob Thumbs Up
  
Post #171197828th Sep 2016 5:42 am
View user's profile Send private message View poster's gallery Reply with quote
discostick
 


Member Since: 08 Nov 2012
Location: Kent
Posts: 286

United Kingdom 2005 Discovery 3 TDV6 S Manual Bonatti GreyDiscovery 3

Hi Bob,

Sorry for the late reply to this!

Im sure i can get something together for you. Give me a few days and il let you know....

James
 New Engine - Fitted with body on...

Developer of the FBH Smart Control Module - Keyfob 3rd button control + USB Diagnostics + remote status LED + priming + battery protection + water temp control setpoint (or fixed run time)

Group Buy: www.disco3.co.uk/forum/post1405044.html#1405044
Downloads: www.dropbox.com/sh/swqlepn6jdb7g5l/AAD5avF_KIexlhlQf4--kysZa?dl=0
FBH not Starting?: www.disco3.co.uk/forum/fixed-webasto-fbh-105563.html
E: d3discostick@gmail.com 
 
Post #17151514th Oct 2016 7:25 am
View user's profile Send private message View poster's gallery Send e-mail Reply with quote
bobmclane
 


Member Since: 27 Dec 2014
Location: Ipswich
Posts: 48

United Kingdom 2005 Discovery 3 TDV6 SE Manual Java BlackDiscovery 3

No worries Jay, totally understand Smile

I've PM'd you also if you want to discuss out of this thread....

Thanks so much for getting back to me Thumbs Up

Cheers
Bob
  
Post #17153644th Oct 2016 5:39 pm
View user's profile Send private message View poster's gallery Reply with quote
bobmclane
 


Member Since: 27 Dec 2014
Location: Ipswich
Posts: 48

United Kingdom 2005 Discovery 3 TDV6 SE Manual Java BlackDiscovery 3

Hi James,

Sorry to be a pain as I'm sure your a busy fella Embarassed but any updates on this?
I'm happy to give it a bash myself (been a little while without using the soldering iron Wink but can try to buy the specified parts and follow your instructions or equally buy one of these from you if you have a spare one kicking about...
Just want to try and get one in place before the cold weather sets in and the missus kills me if stranded somewhere if she can't start it Whistle trust me my life won't be worth living Rolling Eyes

Thanks again mate...

Cheers
Bob

PS Please PM me your email if that works better to communicate
  
Post #17169388th Oct 2016 11:35 am
View user's profile Send private message View poster's gallery Reply with quote
Display posts from the last:  
Post Reply Back to top
Page 10 of 15 <123 ... 91011 ... 131415>
Jump to:  
Previous Topic | Next Topic >


Posting Rules
You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum



DISCO3.CO.UK Copyright © 2004-2024 Futuranet Ltd & Martin Lewis
DISCO3.CO.UK RSS Feed - All Forums

DISCO3.CO.UK is independent and not affiliated to Land Rover.
Switch to Mobile Site